Refine
Document Type
- Part of a Book (27) (remove)
Has Fulltext
- yes (27)
Keywords
- Biogas (7)
- :metabolon (2)
- CALB (2)
- Esterification (2)
- Industrial biogas plant (2)
- Kläranlage (2)
- Lagerung (2)
- Lipase (2)
- Nitrification (2)
- On-demand production (2)
Faculty
- Angewandte Naturwissenschaften (F11) (14)
- Fakultät 10 / :metabolon Institut (9)
- Fakultät 09 / Cologne Institute for Renewable Energy (2)
- Fakultät 10 / Institut für Automation & Industrial IT (2)
- Fakultät 09 / Institut für Bau- und Landmaschinentechnik (1)
- Fakultät 12 / Institut für Technologie und Ressourcenmanagement in den Tropen und Subtropen (1)
This paper presents a series of flow and temperature measurements on the principal heat network of :metabolon in Lindlar, Germany. These measurements intend to show the behaviour of the system on specific production areas of :metabolon for future monitoring and optimisation purposes. Such measurements allow the analysis of the system’s heat flow through the network, which showed that losses exist, some areas. The results demonstrate successfully that the temperature and flow changes deserve more detailed and fixed monitoring in specific areas to help the user decide the optimum measuring point.
The utilization of roadside-green-cuttings (grass) for anaerobic digestion increases provides an additional possible source of organic waste for use as a renewable energy source. Grass can be used as a substrate to increase biogas yield. Nevertheless, the anaerobic digestion of this kind of waste can be limited due to the fact that it could be contaminated with heavy metals, in particular from traffic emissions and industrial activity. For this reason the biogas production of grass from a busy road was assessed. Samples of roadside-grass were washed with an organosulphide, which is used for the removal of heavy metals from wastewater.
A comparison of the anaerobic digestion of washed and unwashed roadside grass was performed. Results showed that the anaerobic digestion of the unwashed grass was much more effective than the washed grass. A second experiment was carried out and co-fermentation of manure and farm-grass was prepared for anaerobic digestion. Lead was added in the concentrations 500, 1000 and 2000 mg Pb2+/kg. The results showed that the higher the lead concentration, the lower the inhibition of the biogas yield. The grass could be acting as phytoremediator for high lead concentrations. The grass could contain organic compounds, which can as-similate heavy metals.
Anaerobic Digestion of spent grains: Potential use in small-scale Biogas Digesters in Jos, Nigeria
(2014)
In order to ascertain biogas yield potential and applicability of spent grains (SG)1 in small-scale biogas production, laboratory batch fermentation was performed with various masses of dry and wet SG using sewage sludge (SS)2 and digested maize silage (DMs) 3 as inoculums. Different volumes of biogas and CH4 were measured with higher volumes observed for batch fermentation with DMs in com-parison to those produced by SS. Results from the study reveals minimum biogas yield of 118.10 L/kg
VS and maximum yields of 769.46 L/kg VS, which are indicative of the possible use of SG for domestic biogas production in Jos, Nigeria. The study established the fact that the use of both dry and wet SG results in the yield of a useful amount of biogas having 40 - 60 % CH4 content depending on the inoculum and amount of volatile solids present. Using the parameters of dry matter and volatile solids contents analysed for SG and DMs, it was estimated that a reactor volume of 6.47 m3 would be capable of meeting the daily cooking needs of rural households in Jos, Nigeria.
Biogas, mit geringen Konzentrationen an Methan, entsteht unter anderem bei verschiedenen industriellen Prozessen. Wegen der Umweltschädlichkeit des Methans gilt es dessen Eintrag in die Umwelt zu vermeiden.
Das Ziel des vorgestellten Projektes war die Überprüfung eines umweltfreundlichen Verfahrens zur Reduzierung des Methans durch methanotrophe Bakterien. Die einzelnen Batchversuche liefen über 15 Stunden und zeigten eine starke Reduzierung des Methans von 18 auf 1 Vol.-%.
Comparative analysis of non-natural acceptor glucosylation with sucrase enzymes of family GH 70
(2019)
Mutan- and alternansucrase were analyzed for their non-natural glucosylation potential with catecholic compounds caffeic acid and nordihydroguaiaretic acid (NDGA) as well as with non-catecolic p-coumaric acid and umbellic acid. Mutansucrase accepted both catecholic substrates and high glucosylation yields of 92 % with caffeic acid and 81 % with NDGA were obtained. The enzyme showed a clear regio-preference for the catechol 4-OH, which corresponds to findings from our previous work with Leuconostoc and Weissella derived glucansucrases. The substrate spectrum of the alternansucrase was broader and all substrates were successfully glucosylated with a preference for the catechols. Interestingly alternansucrase possessed a different regio-specificity. With caffeic acid the 3-O-α-D-glucoside was the major product. A similar substrate spectrum and regioselectivity pattern was observed in previous glucansucrase screenings only with glucansucrase from strain Weissella beninensis DSM 22752. Therefore it may be concluded that the W. beninensis enzyme is an alternansucrase type enzyme as well.
Modern industrial biomass combustion plants are regulated by the power and/or combustion control. In this process, the implemented sensors collect the relevant measured data. The aim is to achieve ideal combustion with optimum efficiency and to minimize gas emissions. For this purpose, a group within the research project Metabolon developed new regulatory procedures in order to record the combustion process of a biomass combustion plant using a webcam. The recordings were evaluated automatically and were used for a better monitoring of the process. In addition, the webcam-based method aims, among other things, to provide private homes with a cost-effective variant as an alternative to industrial system solutions.
Mit Einführung der Deponieverordnung 2005 endete die Deponierung nicht-inerter Stoffe und biologisch aktiver Spezies. Im Zuge ihrer Durchsetzung traten neue Behandlungsmöglichkeiten dieser Stoffströme in das Zentrum der Betrachtung. Zu diesen Behandlungsmethoden zählt die anaerobe biologische Behandlung. Sie findet vor allem bei stark organisch geprägten Stoffströmen mit hohen Wassergehalten Anwendung (Kaltschmitt et al. 2009). Im Zuge der anaeroben Behandlung werden organische Kohlenstoffverbindungen hauptsächlich in CO2 und CH4 umgesetzt. Die anaerobe Behandlung reduziert so den organischen Anteil und das Volumen des Gärsubstrates. Im Gegenzug steigt der Wasseranteil des Gärsubstrates durch die Freisetzung von Zellwasser an. Verbindungen aus Phosphor und Stickstoff verbleiben im Gärsubstrat und machen es damit zu einem geeigneten Düngemittel für die Landwirt-schaft (Möller et al. 2009). Das Material unterliegt der Düngemittelverordnung, durch welche sowohl die Ausbringung als auch die Ansprüche an dessen Beschaffenheit geregelt werden. Um den anfallenden Gärrest für die Landwirtschaft nutzen zu können, muss daher eine Möglichkeit zur mittelfristigen Lagerung geschaffen werden (Raussen et al. 2008). Über das Verhalten im Zeitraum dieser Lagerung gibt es bisher nur wenige Untersuchungen. Grund hierfür ist vor allem die hohe Diversität des Presswassers. Dessen Eigenschaften werden durch die Betriebsparameter der Biogasanlage bestimmt und unterscheiden sich so deutlich von Anlage zu Anlage.
Die hier dargestellten Arbeiten sind Teil eines Forschungsvorhabens zur Untersuchung des Lagerungsverhaltens von Presswasser aus der Vergärungs- und Kompostierungsanlage Leppe. Diese verfügt über zwei Lagerungsbehälter mit einem Fassungsvermögen von je 3.500 m³. Bereits im Zuge der Planung wurde ein anaerober und aerober Betrieb vorgesehen. Neben den drei Rührwerken, mit denen die Durchmischung des Presswassers gewährleistet wird, sind zwei Injektionsbelüfter installiert.
Ziel der Untersuchungen war es, eine Datengrundlage zu schaffen, aufgrund derer über die Betriebsweise der Presswasserspeicher entschieden werden kann.
Mit Hilfe der Inline-ATR-FTIR-Spektroskopie im mittelinfraroten (MIR) Spektralbereich lassen sich gleich mehrere Prozessparameter für Biogasanlagen in Echtzeit und ohne Probenahme verfolgen. Die gemessenen Absorptionsspektren geben simultan Aufschluss über den Gehalt an flüchtigen organischen Säuren (FOS), die alkalische Pufferkapazität (TAC) und die Ammoniumstickstoff-Konzentration (NH4-N).
Dabei können unter Verwendung intelligenter Datenanalyseverfahren, wie z.B. Partial Least Squares (PLS), Regression oder Support Vector Regression (SVR) sowie in kontrollierter Laborumgebung, Vorhersagefehler (RMSECV) von 0.372 g/l (FOS: R2=0.971), 0.336 g/l (TAC: R2=0.996) und 0.171 g/l (NH4-N: R2=0.992) im Falle der PLS, bzw. 0.386, 0.259 und 0.110 g/l für die SVR erreicht werden.
Erste Inline-Messungen in einer Biomüllvergärungsanlage zeigen, dass die erwarteten Absorptionsbanden auch im Prozessbetrieb wiedergefunden werden können. Sie unterliegen jedoch einem ausgeprägten Temperatureinfluss, der bei der Quantifizierung dieser Prozessdaten berücksichtigt werden muss. Weiterführende Untersuchungen sind notwendig, um die Inline-Tauglichkeit des Messsystems unter Beweis zu stellen.
The introduction of Feed-in tariffs in the German Renewable Energy Act (EEG) fuelled the growth of anaerobic digestion (AD) industry making Germany the country with highest number of operational AD plants. However, the rapid expansion of AD industry resulted in some unwanted side-effects such as food vs fuel debate, increased prices for electricity and the temporal mismatch between supply and demand of electricity grid. Subsequent amendments in EEG has tried to address some of these issues by reduction in Feed-in tariffs, introduction of a cap on cereal based feedstocks and providing premium for energy production in accordance with market demand. Furthermore, the Feed-in tariffs which were introduced for 20 years are soon going to expire. The changes in legal and political discourse is soon going to introduce some new challanges to the AD industry. This paper has discussed some of these challanges and their potential solutions.
Für einen aktiven Gewässerschutz ist es sinnvoll,
Immissionen aus Kläranlagen und Kanalsystemen
in einem Gesamtkonzept zu betrachten und somit
das Abwasserabflusssystem ganzheitlich zu bewirtschaften.
Schließlich belasten diese Einleitungen
die Gewässer sowohl in hydraulischer wie auch in
stofflicher Hinsicht.
Die gewonnenen Erfahrungen aus fünfjähriger Forschungsarbeit
stellen die Grundlage für einen erfolgreichen
Technologietransfer auf weitere Kanal und
Kläranlagen-Systeme dar. Dies ist ein wesentliches
Ziel des wissenschaftlichen Netzwerkes, das
im Rahmen von :metabolon aufgebaut wird.